Difference between revisions of "16683/P0299/000665"

From Ross-Tech Wiki
Line 32: Line 32:
 
** When stored in conjunction with misfire codes and/or fuel trim faults see the notes associated with the following faults regarding PCV failure: [[18711/P2279/008825|P2279]], [[17544/P1136/004406|P1136]], [[17705/P1297/004759|P1297]], [[17501/P1093/004243|P1093]] and/or [[16891/P0507/001287|P0507]].
 
** When stored in conjunction with misfire codes and/or fuel trim faults see the notes associated with the following faults regarding PCV failure: [[18711/P2279/008825|P2279]], [[17544/P1136/004406|P1136]], [[17705/P1297/004759|P1297]], [[17501/P1093/004243|P1093]] and/or [[16891/P0507/001287|P0507]].
  
* When found in [[Audi A4/S4/RS4/Cabriolet (8K)]]: 2.0l (CAEB):
+
* When found in 2009-2012 Audi with CAEB engine:
 
** See TPI 2031245 -  turbocharger excessive waste gate play.
 
** See TPI 2031245 -  turbocharger excessive waste gate play.
 
*** https://static.nhtsa.gov/odi/tsbs/2013/SB-10052519-6931.pdf  NHTSA
 
*** https://static.nhtsa.gov/odi/tsbs/2013/SB-10052519-6931.pdf  NHTSA

Revision as of 15:19, 18 March 2021

16683/P0299/000665 - Boost Pressure Regulation: Control Range Not Reached

Possible Symptoms

  • Reduced Power Output
  • Limp Mode

Possible Causes

  • Hoses/Pipes incorrect connected, disconnected or leaking
  • Charger Pressure Control defective
  • Turbocharger faulty
  • Diverter Valve faulty

Possible Solutions

  • Check Hoses/Pipes to/between Components
  • Check / Clean / Replace Charge Pressure Control
  • Check Turbocharger
  • Check Diverter Valve

Special Notes

  • If the Turbocharger is faulty due to mechanical / internal problems or the exhaust system is restricted (typically the Catalyst) this fault may be the end result.
Gasoline
  • When found in 2.0l TFSI:
    • Check Boost Pressure Control Valve (N249), for cracked rubber diaphragm. A new/optimized Valve is available under Part # 06H-145-710-D (or newer).
      • RoW vehicles see: TPI 2016331 for details.
      • NAR vehicles see: TSB 01-07-70 or 2013392 for details.
    • When stored in conjunction with misfire codes and/or fuel trim faults see the notes associated with the following faults regarding PCV failure: P2279, P1136, P1297, P1093 and/or P0507.
  • When found in All 2008 to 2015 Volkswagen vehicles with the 2.0L TSI Engines (codes CCTA and CBFA)
    • See Volkswagen Tech Tip 21-10-02.
      • https://static.nhtsa.gov/odi/tsbs/2015/MC-10122981-9999.pdf NHTSA
      • This Tech Tip suggests to check if the wastegate valve and lever has dropped and become stuck/seized causing either an over-boost or under-boost fault. P0299, P0234 or P0236.
      • This concern can be intermittent also clearance between the turbocharger housing and the wastegate lever should be about 3.0mm.
Diesel
  • When found in VW Golf/Jetta (1K): 2.0l CR-TDI (CBEA/CJAA):
    • Verify the mechanical part of the Exhaust Valve Control Module (J883) is not seized or binding.
  • When found in the 1.9 L TDI-PD (BLS):
    • Check vacuum supply from the vacuum reservoir located in the valve cover for leaks. Using a vacuum gauge, wiggle the valve cover and hose connections to check for a leak. The following photo was submitted from a customer working on a 2010 VW Caddy (2K chassis) with this vacuum reservoir problem.