Difference between revisions of "16785/P0401/001025"

From Ross-Tech Wiki
 
(4 intermediate revisions by 2 users not shown)
Line 24: Line 24:
 
==== Special Notes ====
 
==== Special Notes ====
  
 +
When this fault is stored in a 2009-2012 NAR market [[2.0L CR TDI]] (CBEA, CJAA, CKRA) VW Jetta/Golf (1K/AJ) or the NMS Passat (A3) chassis:
 +
*Please see: TSB 26-13-03 | TPI# 2031583/3 (''formerly know as 26-12-08 | TPI# 2031583'').  When the Exhaust Pressure Flap Control Module (J883) is faulty, the engine controller may have any of the following DTCs:
 +
**[[P047F/00115 | P047F/001151 - Exhaust Pressure Control Valve: Stuck Open]]
 +
**P0477 - Exhaust Pressure Control Valve "A" Low
 +
**[[P048A/001162 | P048A/001162 - Exhaust Pressure Control Valve 1: Stuck Closed]]
 +
**P048B - Exhaust Pressure Control Valve "A" Position Sensor/Switch Circuit
 +
**P048C - Exhaust Pressure Control Valve "A" Position Sensor/Switch Circuit Range/Performance
 +
**[[16785/P0401/001025 | 16785/P0401/001025 - Exhaust Gas Recirculation (EGR) System: Insufficient Flow Detected]]
 
* Some TDI-CR engines have a filter for the EGR that can become restricted and cause a "Insufficient Flow" code.  
 
* Some TDI-CR engines have a filter for the EGR that can become restricted and cause a "Insufficient Flow" code.  
 +
 +
 +
When this fault is stored in a 2009-2014 NAR market [[2.0L CR TDI]] (CBEA or CJAA ) VW Jetta/Golf (1K/AJ)
 +
*Please See TSB 01 14 11(''Updated: 01 14 21'') | TPI# 2034898
 +
** May also have fault code stored in ECM
 +
***[[18895/P2463/009315 | 18895/P2463/009315 - Diesel Particle Filter: Excessive Soot Accumulation]]
 +
* Restrictions in the EGR Filter may occur after a regeneration, if the soot loads where high before the regeneration.
  
 
[[Category:Fault Codes]]
 
[[Category:Fault Codes]]

Latest revision as of 12:36, 6 October 2015

16785/P0401/001025 - Exhaust Gas Recirculation (EGR) System: Insufficient Flow Detected

Possible Symptoms

  • Malfunction Indicator Light (MIL) ON
  • Reduced Exhaust Gas Recirculation (EGR)
  • Reduced Power Output/Engine running rough
  • Increased Emissions

Possible Causes

  • Exhaust Gas Recirculation (EGR) Flow restricted/clogged
  • Exhaust Gas Recirculation (EGR) Valve stuck closed/leaking/faulty
  • Wiring and/or Connector(s) from/to Exhaust Gas Recirculation (EGR) Valve faulty
  • Exhaust Gas Recirculation (EGR) System faulty

Possible Solutions

  • Check/Clean Exhaust Gas Recirculation (EGR) System
  • Check/Replace Exhaust Gas Recirculation (EGR) Valve
  • Check Wiring and/or Connector(s) from/to Exhaust Gas Recirculation (EGR) Valve

Special Notes

When this fault is stored in a 2009-2012 NAR market 2.0L CR TDI (CBEA, CJAA, CKRA) VW Jetta/Golf (1K/AJ) or the NMS Passat (A3) chassis:


When this fault is stored in a 2009-2014 NAR market 2.0L CR TDI (CBEA or CJAA ) VW Jetta/Golf (1K/AJ)