Difference between revisions of "16683/P0299/000665"
From Ross-Tech Wiki
| Line 37: | Line 37: | ||
* When found in All 2008 to 2015 Volkswagen vehicles with the 2.0L TSI Engines (codes CCTA and CBFA) | * When found in All 2008 to 2015 Volkswagen vehicles with the 2.0L TSI Engines (codes CCTA and CBFA) | ||
| − | ** See Volkswagen Tech Tip 21-10-02 | + | ** See Volkswagen Tech Tip 21-10-02. |
| + | *** https://static.nhtsa.gov/odi/tsbs/2015/MC-10122981-9999.pdf NHTSA | ||
*** This Tech Tip suggests to check if the wastegate valve and lever has dropped and become stuck/seized causing either an over-boost or under-boost fault. P0299, [[16618/P0234/000564|P0234]] or P0236. | *** This Tech Tip suggests to check if the wastegate valve and lever has dropped and become stuck/seized causing either an over-boost or under-boost fault. P0299, [[16618/P0234/000564|P0234]] or P0236. | ||
*** This concern can be intermittent also clearance between the turbocharger housing and the wastegate lever should be about 3.0mm. | *** This concern can be intermittent also clearance between the turbocharger housing and the wastegate lever should be about 3.0mm. | ||
Revision as of 09:45, 3 March 2021
16683/P0299/000665 - Boost Pressure Regulation: Control Range Not Reached
Possible Symptoms
- Reduced Power Output
- Limp Mode
Possible Causes
- Hoses/Pipes incorrect connected, disconnected or leaking
- Charger Pressure Control defective
- Turbocharger faulty
- Diverter Valve faulty
Possible Solutions
- Check Hoses/Pipes to/between Components
- Check / Clean / Replace Charge Pressure Control
- Check Turbocharger
- Check Diverter Valve
Special Notes
- If the Turbocharger is faulty due to mechanical / internal problems or the exhaust system is restricted (typically the Catalyst) this fault may be the end result.
Gasoline
- When found in 2.0l TFSI:
- Check Boost Pressure Control Valve (N249), for cracked rubber diaphragm. A new/optimized Valve is available under Part # 06H-145-710-D (or newer).
- RoW vehicles see: TPI 2016331 for details.
- NAR vehicles see: TSB 01-07-70 or 2013392 for details.
- When stored in conjunction with misfire codes and/or fuel trim faults see the notes associated with the following faults regarding PCV failure: P2279, P1136, P1297, P1093 and/or P0507.
- Check Boost Pressure Control Valve (N249), for cracked rubber diaphragm. A new/optimized Valve is available under Part # 06H-145-710-D (or newer).
- When found in Audi A4/S4/RS4/Cabriolet (8K): 2.0l (CAEB):
- See TPI 2031245 - turbocharger excessive waste gate play.
- http://www.youtube.com/watch?v=efWOPtAw1Ss shows an example of excessive waste gate play.
- When found in All 2008 to 2015 Volkswagen vehicles with the 2.0L TSI Engines (codes CCTA and CBFA)
- See Volkswagen Tech Tip 21-10-02.
- https://static.nhtsa.gov/odi/tsbs/2015/MC-10122981-9999.pdf NHTSA
- This Tech Tip suggests to check if the wastegate valve and lever has dropped and become stuck/seized causing either an over-boost or under-boost fault. P0299, P0234 or P0236.
- This concern can be intermittent also clearance between the turbocharger housing and the wastegate lever should be about 3.0mm.
- See Volkswagen Tech Tip 21-10-02.
Diesel
- When found in VW Golf/Jetta (1K): 2.0l CR-TDI (CBEA/CJAA):
- Verify the mechanical part of the Exhaust Valve Control Module (J883) is not seized or binding.
- When found in the 1.9 L TDI-PD (BLS):
- Check vacuum supply from the vacuum reservoir located in the valve cover for leaks. Using a vacuum gauge, wiggle the valve cover and hose connections to check for a leak. The following photo was submitted from a customer working on a 2010 VW Caddy (2K chassis) with this vacuum reservoir problem.
